GM could face another fine for Impala recall

An old e-mail from a General Motors employee warning of a "serious safety problem" could help trigger another government fine against the automaker.
AP Wire
Jun 20, 2014

The Aug. 30, 2005, e-mail surfaced Wednesday during a House subcommittee hearing on GM's delayed recall of 2.6 million small cars with ignition switch problem. This email outlined a similar issue with a larger car.

Employee Laura Andres wrote that she was driving a 2006 Chevrolet Impala home from work when she hit a bump and the engine stalled on busy Interstate 75 near Detroit. The car behind her had to swerve to avoid a crash. A GM mechanic told her the cause was likely a faulty ignition switch.

"I think this is a serious safety problem ... I'm thinking big recall," Andres wrote in an e-mail to 11 GM colleagues.

Yet it wasn't until Monday that GM recalled the Impalas, Buick LaCrosses and other models with the same switch, almost nine years after Andres' e-mail. Safety regulators received dozens of similar complaints about the cars during that time.

GM said that excess weight on a keychain could cause the ignition switch to move out of the "run" position if the car is jarred, like when it hits a pothole. The engine stalls, and the drivers loses power steering and power brakes.

Under federal law, automakers must notify the National Highway Traffic Safety Administration within five business days of determining a safety defect exists. A maximum $35 million fine is possible if the agency finds an automaker took too long to report a problem.

GM paid a $35 million fine last month for its 11-year delay in reporting defective ignition switches in the Chevrolet Cobalt and other small cars.

Multiple fines are not without precedent. From 2010 through 2012, NHTSA fined Toyota Motor Corp. four times for a total of $66 million due to safety-related violations.

GM wouldn't comment Thursday on the possibility of another fine. NHTSA also wouldn't comment on the Impala case, but said it reviews all recalls to make sure they comply with the notification law and it takes "appropriate action" when it finds problems.

Andres's e-mail alone isn't enough to trigger the five-day rule, because it only suggests the ignitions are unsafe. But it's proof that some GM employees knew about a potential problem for almost a decade. GM has not yet submitted a required timeline to NHTSA that will say when it officially determined the Impala switches were defective.

Andres, who still works for GM in design and engineering, could not be reached for comment. But in her 2005 e-mail, she urged engineers to build a "stronger" switch.

Andres' warning was brushed off by GM engineer Ray DeGiorgio, who replied that he had recently driven a 2006 Impala and "did not experience this condition." He also noted that the Impala had "a completely different column/ignition switch" than the one that was causing problems in GM's small cars.

DeGiorgio is a central figure in the small-car recall saga. GM says he approved using the switches even though they failed to meet company specifications, and then took actions that hid the defect for years.

Andres's e-mail wasn't the only indication of problems. NHTSA's Web site lists more than 100 complaints about stalling for 2006-2009 Impalas alone. Those are complaints GM would have had access to.

In one 2012 complaint, an Impala stalled in the middle of a large intersection. The owner took it to a dealer four times but couldn't get it repaired.

"I'm fearful I will be the one causing a fatal pile-up," the driver wrote.

 

Comments

happycamper

And you wonder why us american,s are buying foreign

Ole

And you wonder why we're buying a Ford, the company that didn't take the bailout . . . . .

Lanivan

Not even Ford can 'escape' the recall list:

Ford Recalls 1.4 Million SUVS and Cars - May 29, 2014. Christian Science Monitor.

FanoBucs

Really! I have been driving an IMPALA and I have well over 200,000 miles on this car. It looks good, (no rust) and it get great gas miliage. It has been a great car that will drive for a while longer. No problems at all with this car.

Wolverine49457

I'd been a loyal GM customer for many years but bought a Kia, it's almost paid off and no one trouble or complaint. When it's time to buy a truck will be a Ford or Toyota, I've just bought too many transmissions and rear end assemblies for GM trucks that were not overworked by any stretch. It's sad to see such an American icon such as GM being managed into chaos and calamity with bills we didn't get a vote on we must now pay and engineers who didn’t communicate resulting in the deaths of customers, I’m no Jack Welch but my advice to GM is you should avoid killing your customers at all cost, even if it means you have to talk to each other once in a while.

Ole

March 2014 total Chevy GM recalls for that month alone approx. 4.7 million. 03/29/2014 AP release
Even foreign auto manufacturers have periodic recalls, it is the frequency and total #s of recalls for Chevy/GM in the past 2 yrs alone that is pretty disturbing. Just for the record, I drive an '01 F150 and my wife drives an '03 Hyundai Santa Fe. Regular problem with the truck is the regular failure of an ignition coil (4 out of the eight in the past 8 yrs) and lackluster MPG, best I've ever gotten is 14 to the gallon. My wife loves her Santa Fe, only one minor recall and I don't recall what for at all . . . .

Post a Comment

Log in to your account to post comments here and on other stories, galleries and polls. Share your thoughts and reply to comments posted by others. Don't have an account on GrandHavenTribune.com? Create a new account today to get started.